Action by John Lynch against Ninemire Packing Company, a corporation, to recover damages for personal injuries. From a nonsuit and order of dismissal, the plaintiff has appealed.
Appellant contends the trial judge erred in sustaining respondent’s motion for a nonsuit. The evidence shows the following facts: Respondent was operating a wholesale meat and packing establishment in Aberdeen, and had installed in its plant a large vat for rendering tallow. In the vat were two openings, one above for receiving the materials, and one below for discharging the same after rendering. The lower opening could be closed by adjusting a swinging trapdoor, around the edge of which burlap was inserted to pre*424vent leaking. The door when closed was held by a clamp hooked over a rim on the vat, and securely fastened with an eye bolt passing through the clamp and door. The tallow was rendered by means of steam conducted into the closed vat from an engine and boiler which generated about eighty pounds pressure. The pressure in the vat was reduced and controlled at about forty to forty-five pounds by a suitable gauge provided for that purpose. The appellant was in exclusive charge of the vat, engine, boiler, and equipment. He had been thus employed for about eighteen months, but insists he was not an experienced or expert engineer.
On the evening of March 1, 1909, appellant adjusted, closed, and fastened the trapdoor over the lower opening. On the next morning he filled the vat from above with proper materials for rendering, closed the upper opening, turned on the steam, examined the gauge, noticed the pressure in the vat did not exceed forty to forty-five pounds, went into the engine room to look after the steam and boiler, returned to the vat, noticed that it was leaking, and to stop the leaking, tightened the clamp by turning the eye bolt. Shortly thereafter, while he was performing other necessary work near the vat, it suddenly exploded and caused him to be burned by hot tallow which escaped about him. The vat was thrown some two hundred feet, and after the accident it was discovered the clamp had been broken at the point where the eye bolt had passed through. No evidence was introduced sufficient to show whether the breaking of the clamp caused the explosion or the explosion caused its breaking. These various appliances had been successfully and continuously used for about two and a half years, no complaint being made of their fitness, suitability, or condition of repair.
Appellant’s controlling contention is that the respondent, his master, did not provide him with a reasonably safe place in which to work, nor with reasonably safe appliances; and that the doctrine of res ipsa loquitur should be applied to this case, as one in which the accident itself suggests negligence *425on the part of the master. In support of these contentions he cites, Beall v. Seattle, 28 Wash. 593, 69 Pac. 12, 92 Am. St. 892, 61 L. R. A. 583; Klepsch v. Donald, 4 Wash. 436, 30 Pac. 991, 31 Am. St. 936; LaBee v. Sultan Logging Co., 47 Wash. 57, 91 Pac. 560, 20 L. R. A. (N. S.) 405; Id., 51 Wash. 81, 97 Pac. 1104; Cleary v. General Contracting Co., 53 Wash. 254, 101 Pac. 888, and Riggs v. Northern Pac. R. Co., 60 Wash. 292, 111 Pac. 162. He contends that, when it had been made to appear from the evidence that he was properly using an instrumentality furnished by his master, which failed to perform its functions and exploded without fault on his part, he had made a prima facie case of negligence on the part of the master, under the doctrine of res ipsa loquitur; and that it then devolved upon the respondent to show by competent evidence that it was without fault, or that the accident occurred without negligence on is part.
It is true that, in the cases cited, this court'applied the doctrine of res ipsa loquitur to the facts shown, and that in some of them the relation of master and servant existed. But in none of them did the servant have complete charge of the alleged defective appliances, in the sense that at the time he was exclusively using and controlling them. Appellant, as the respondent’s servant, had exclusive control and supervision of all the áppliances at the time of the explosion, and for a considerable period immediately prior thereto. The maxim of res ipsa loquitur is applied in negligence cases on the theory that the accident, in the light of surrounding circumstances, is of such a character as to raise a presumption of negligence from the occurrence itself; and on the further theory, that the injured party is not in a position to explain its cause; while the party charged, having more favorable opportunities, is in a position to thus explain and show himself free from negligence, if such be the case. If the circumstances do not suggest or indicate superior knowledge or opportunity for explanation on the part of the party charged, *426or if the plaintiff himself has equal or superior means of information, the doctrine will not apply.
In Beall v. Seattle, a pedestrian on a city sidewalk was injured by the explosion of a boiler wrongfully installed and maintained beneath the sidewalk, of which boiler he could not and did not have any knowledge. In Klepsch v. Donald, the plaintiff was injured by a stone thrown some distance from a blast with which he had no connection. In LaBee v. Sultan Logging Co., the plaintiff was injured by the breaking of a cable which had not been placed, inspected, or in any manner regulated by him. He was not using the cable at the time of the accident. It was broken by a strain imposed under the direction of a vice principal of the master, who was then upon the ground. In Cleary v. General Contracting Co., the plaintiff used a scaffold prepared for him by the defendant. He had nothing to do with its adjustment or construction. In Riggs v. Northern Pac. R. Co., a brakeman in the course of his employment seized a defective 'handhold, which he had not theretofore inspected or used. In the LaBee case, in 51 Wash. 82, 97 Pac. 1104, we said:
“Where the facts of the case are such as to eliminate blame on the part of the servant, or his fellow servants, but show prima facie neglect on the part of some one, we think the master should be put to his proofs to show.that the blame is not his, just the same as he would be were the. injury to a stranger. Such a rule casts the burden upon the person who is in a position to know the facts, and who can make the proofs by direct and positive evidence, while the rule contended for by the appellant compels the resort to indirect and circumstantial evidence.”
This doctrine should not be applied to the facts before us. Appellant necessarily possessed superior knowledge as to the instrumentalities he was adjusting, operating, and using. Under such conditions, if a servant happens to be injured by the failure of an instrumentality to perform its ordinary functions, it is but just that some affirmative negligence be fixed upon the master to hold him liable, his knowledge of *427the true cause of such failure being inferior to, or at least not superior to, that of the servant. Appellant testified he had done nothing out of the ordinary, thereby seeldng to eliminate negligence on his part. If, however, the doctrine for which he contends is to be applied to such a case as this, the master would be at the mercy of a servant, who might do many things in the course of his employment, unknown to the master, which would contribute to or cause the accident.
In Losie v. Delaware & H. Co., 126 N. Y. Supp. 871, the court said:
“The doctrine of res ipsa loquitur was not intended to exempt the plaintiff from the burden of proving affirmatively negligence, or circumstances making negligence a legitimate, if not an irresistible, inference. In the language of Judge Cullen in Griffen v. Manice, 166 N. Y. 188, 59 N. E. 925, 52 L. R. A. 922, 82 Am. St. Rep. 630, its ‘application presents principally the question of the sufficiency of circumstantial evidence to establish, or to justify the jury in inferring, the existence of the traversable or principal fact in issue, the defendant’s negligence.’ It is not the accident, but the manner and circumstances of the accident, that justifies the application of the maxim. The fact of the casualty and the attending circumstances may themselves furnish all the proof of negligence that it is necessary to offer; but when, as in this case, they do not, a plaintiff must prove facts and circumstances from which the jury may fairly infer negligence as the cause of the accident. ‘In no instance can the bare fact that an injury has happened, of itself and divorced from all surrounding circumstances, justify the inference that the injury was caused by negligence.’ Benedick v. Potts, 88 Md. 52, 40 Atl. 1067, 41 L. R. A. 478; Griffen v. Manice, supra.”
In the LaBee and other cases cited by appellant, we held that, under proper conditions and circumstances, we would not deny an application of the doctrine of res ipsa loquitur to negligence cases arising between master and servant. But when machinery, instrumentalities, or appliances are prepared for use and operated by the injured servant himself, without the direction, intervention, or supervision of the *428master, and the servant, being in exclusive charge, controls and directs them, it would then appear that the circumstances-were not such as to necessarily raise a presumption of negligence on the part of the master and subject him to the application of the maxim. The master, not being in control, would be at a much greater disadvantage in attempting to account for the accident and explain its true cause than would the servant. In Griffen v. Manice, 166 N. Y. 188, 59 N. E. 926, 82 Am. St. 630, 52 L. R. A. 922, the court, in discussing one theory upon which the maxim is based, said:
“The maxim is also in part based on the consideration-that where the management and control of the thing which? has produced the injury is exclusively vested in the defendant, it is within his power to produce evidence of the actual cause that produced the accident, which the plaintiff is unable to present.”
Here the management and control were not exclusively-vested in the respondent. In an action of this character, there-must be some reasonable showing of negligence to require the submission of that issue to the jury. Where the offending appliances or instrumentalities are shown to have been under the exclusive control of the defendant, and the accident in-its nature, circumstances, and surroundings is such as in ordinary course would not occur with reasonable care on the-part of the defendant, then, in the absence of an explanation by him, the accident itself might afford a-sufficient suggestion of negligence to require an application of the doctrine.. But no such condition appears in this cause. Here appellant, as an employee of respondent, was himself a part of the operating forces and was in a position to have done some act which might have caused or contributed to the explosion. The maxim of res ipsa loquitur may be termed a-rule of evidence, to the extent that, when properly applied, it raises a presumption of negligence • sufficient to make a prima facie case on behalf of the plaintiff, and call for an explanation from the defendant. Mr: Wigmore, in Vol. 4 of his ad*429mirable work on Evidence, at § 2509, page 3556, discussing the maxim, well suggests reasonable limitations to its application, saying:
“With the vast increase, in modern times, of the use of powerful machinery, harmless in normal operation, but capable of serious human injury if not constructed or managed in a specific mode, the question has come to be increasingly common whether the fact of the occurrence of' an injury (unfortunately now termed ‘accident,’ by inveterate misuse) is to be regarded as raising a presumption of culpability on the part of the owner or manager of the apparatus. ‘Res ipsa loquitur’ is the phrase appealed to as symbolizing the argument for such a. presumption. In England, a rule of that sort has for a generation been conceded to exist, for some classes of cases at least. In the United States, the presumption has spread rapidly, although with much looseness, of phrase and indefiniteness of scope; as against a common carrier, the presumption against a bailee (ante, § 2508) has. perhaps helped to confirm the rule where injury to goods, or passengers is involved. What its final accepted shape will be can hardly be predicted. But the following considerations, ought to limit it: (1) The apparatus must be such that in the ordinary instance no injurious operation is to be expected unless from a careless construction, inspection, or user; (2) Both inspection and user must have been at the time of the injury in the control of the party charged; (3) The injurious occurrence or condition must have happened irrespective of any voluntary action at the time by the party injured. It may be added that the particular force and justice of the presumption, regarded as a rule throwing-upon the party charged the duty of producing evidence, consists in the circumstance that' the chief evidence of the true cause, whether culpable or innocent, is practically accessible to him but inaccessible to the injured person.”
Applying the second limitation mentioned, it is apparent, that, at the time of this accident, inspection and user 'were not in control of the respondent. While we have heretofore held that, under proper circumstances and conditions, the maxim of res ipsa loquitur will be applied to the relation of master and servant in negligence cases, we have not held that. *430the mere existence of that relation calls for its application to all such cases. To do so would, in many instances, compel us to ignore the elementary principles on which the doctrine is based, and thereby unjustly place the master at the mercy of a servant who might himself be at fault.
Some exceptions are taken to rulings of the trial court on the admissibility of evidence, but we find no prejudicial error in that regard. The judgment is affirmed.
Dunbar, C. J., Morris, and Chadwick, JJ., concur.